丘陵山地移栽机自动调平系统设计与试验

doi:10.13733/j.jcam.issn.2095-5553.2023.08.003

摘要/Abstract

摘要： 针对丘陵山地移栽机车身在移栽时容易发生倾斜导致移栽效果差的问题，设计一种由状态测量单元、单片机嵌入式系统、电动传动系统组成的移栽机车身自动调平控制系统。首先，综合考虑位置误差调平和角度误差调平优劣势，提出一种多传感器耦合调平策略。其次，采用模糊PID控制器对执行机构中的电动推杆进行控制，并利用卡尔曼滤波器滤除移栽机底盘所受到的发动机振动干扰。然后，通过MATLAB/Simulink对所设计的模糊PID控制器及卡尔曼滤波器进行仿真分析。仿真结果表明，在相同初始参数条件下，模糊PID控制相较于传统PID具有更好的控制性能，系统调节时间缩短62.86%，上升时间缩短47.64%，峰值时间缩短45.54%，最大超调量减少12.23%。卡尔曼滤波器能有效抑制干扰和抖动信号。最后，对车身自动调平控制系统进行静态试验和动态试验。试验结果表明，当车身倾斜角在-8°~8°范围内时，该自动调平系统的调节时间小于3.5s，最大调平误差小于0.5°。当移栽机以3.6km/h的速度行驶时，在起伏较大的路面下车身倾斜角控制在±3°以内，起伏较小的路面下车身倾斜角基本维持在0°，调平速度较快，效果较好，对提高移栽机的移栽效果具有重要意义。

关键词: 移栽机, 自动控制, 调平系统, 卡尔曼滤波, 模糊PID

Abstract: Aiming at the problem that the transplanting effect of the transplanting machine body is poor due to the incline of the transplanting machine body in hilly and mountainous areas, an automatic leveling control system of the transplanting machine body is designed, which is composed of a state measurement unit, a singlechip embedded system and an electric drive system. First, considering the advantages and disadvantages of position error leveling and angle error leveling, a multisensor coupling leveling strategy is proposed. Secondly, the fuzzy PID controller is used to control the electric push rod in the actuator, and the Kalman filter is used to filter out the engine vibration interference from the transplanter chassis. Then, the fuzzy PID controller and Kalman filter designed are simulated and analyzed by MATLAB/Simulink. The simulation results show that under the same initial parameters, fuzzy PID control has better control performance than traditional PID control. The system adjustment time is reduced by 62.86%, the rise time is reduced by 47.64%, the peak time is reduced by 45.54%, and the maximum overshoot is reduced by 12.23%. Kalman filter can effectively suppress interference and jitter signals. Finally, the static and dynamic tests are carried out for the automatic leveling control system of the car body. The test results show that the adjustment time of the automatic leveling system is less than 3.5 s and the maximum leveling error is less than 0.5° when the vehicle body tilt angle is within -8°~8°. When the transplanter is running at a speed of 3.6km/h, the vehicle body tilt angle is controlled within ±3° under the road with large undulation, and the vehicle body tilt angle under the road with small undulation is basically maintained at 0°. The leveling speed is fast and the effect is good, which is of great significance to improve the transplanters transplanting effect.

Key words: transplanting machine, automatic control, leveling system, Kalman filter, fuzzy PID

中图分类号:

S223.92

柯超, 谢守勇, 邓成志, 刘凡一, 刘军, . 丘陵山地移栽机自动调平系统设计与试验[J]. 中国农机化学报, 2023, 44(8): 17-26.

Ke Chao, Xie Shouyong, , Deng Chengzhi, Liu Fanyi, , Liu Jun, . Design and test of automatic leveling system for transplanter in hilly and mountainous areas[J]. Journal of Chinese Agricultural Mechanization, 2023, 44(8): 17-26.

参考文献

［1］　王立浩, 马艳青, 张宝玺. 我国辣椒品种市场需求与育种趋势［J］. 中国蔬菜, 2019(8): 1-4.
［2］　彭月, 吴永红, 王俊莹, 等. 2021年辣椒科学若干领域重要研究进展［J］. 辣椒杂志, 2022, 20(1): 1-11.
Peng Yue, Wu Yonghong, Wang Junying, et al. Important research advances in the selected areas of pepper sciences in 2021 ［J］. Journal of China Capsicum, 2022, 20(1): 1-11.
［3］　陈耿, 彭荣锋, 伍泰旭. 我国辣椒品种市场需求变化趋势及育种对策［J］. 农业与技术, 2019, 39(3): 50-51.
［4］　张新臣. 辣椒大苗机械移栽技术研究与应用［J］. 农业机械, 2020(4): 114-115.
［5］　唐平建, 孙泽林, 宋鹏. 基于模糊PID的液压自动调平与升降控制系统研究［J］. 兵器装备工程学报, 2021, 42(2): 189-193.
Tang Pingjian, Sun Zelin, Song Peng. Research on hydraulic automatic leveling and lifting control system based on fuzzy PID ［J］. Journal of Ordnance Equipment Engineering, 2021, 42(2): 189-193.
［6］　齐文超, 李彦明, 张锦辉, 等. 丘陵山地拖拉机车身调平双闭环模糊PID控制方法［J］. 农业机械学报, 2019, 50(10): 17-23, 34.
Qi Wenchao, Li Yanming, Zhang Jinhui, et al. Double closed loop fuzzy PID control method of tractor body leveling on hills areas ［J］. Transactions of the Chinese Society for Agricultural Machinery, 2019, 50(10): 17-23, 34.
［7］　周浩, 胡炼, 罗锡文, 等. 旋耕机自动调平系统设计与试验［J］. 农业机械学报, 2016, 47(S1): 117-123.
Zhou Hao, Hu Lian, Luo Xiwen, et al. Design and experiment on auto leveling system of rotary tiller ［J］. Transactions of the Chinese Society for Agricultural Machinery, 2016, 47(S1): 117-123.
［8］　胡炼, 林潮兴, 罗锡文, 等. 农机具自动调平控制系统设计与试验［J］. 农业工程学报, 2015, 31(8): 15-20.
Hu Lian, Lin Chaoxing, Luo Xiwen, et al. Design and experiment on auto leveling control system of agricultural implements ［J］. Transactions of the Chinese Society of Agricultural Engineering, 2015, 31(8): 15-20.
［9］　李尚平, 闫昱晓, 徐冰, 等. 丘陵地区剪叉式甘蔗转运车调平控制系统设计与试验［J］. 农业机械学报, 2021, 52(11): 384-393.
Li Shangping, Yan Yuxiao, Xu Bing, et al. Design and experiment on leveling control system of scissor type sugarcane transporter in hilly area ［J］. Transactions of the Chinese Society for Agricultural Machinery, 2021, 52(11): 384-393.
［10］　彭贺, 马文星, 赵恩鹏, 等. 丘陵山地轮式拖拉机车身调平系统设计与物理模型试验［J］. 农业工程学报, 2018, 34(14): 36-44.
Peng He, Ma Wenxing, Zhao Enpeng, et al. Design and physical model experiment of body leveling system for roller tractor in hilly and mountainous region ［J］. Transactions of the Chinese Society of Agricultural Engineering, 2018, 34(14): 36-44.
［11］　孙永佳, 周军, 李学强, 等. 马铃薯联合收获机车身调平系统设计与试验［J］. 农业机械学报, 2020, 51(S1): 298-306.
Sun Yongjia, Zhou Jun, Li Xueqiang, et al. Design and experiment of body leveling system for potato combine harvester ［J］. Transactions of the Chinese Society for Agricultural Machinery, 2020, 51(S1): 298-306.
［12］　赵静一, 杨宇静, 康绍鹏, 等. 自行式液压平板车四点支撑“面追逐式”调平策略的研究与应用［J］. 机床与液压, 2015, 43(15): 57-60.
Zhao Jingyi, Yang Yujing, Kang Shaopeng, et al. Research and application of fourpoint support “Flat Chasing Style” leveling strategy on selfpropelled hydraulic transporter ［J］. Machine Tool & Hydraulics, 2015, 43(15): 57-60.
［13］　陈立坡. 混联自稳跟踪平台及控制系统设计与试验［J］. 农业工程学报, 2018, 34(1): 22-27.
Chen Lipo. Design and experiment of hybrid stabilized tracking platform and its control system ［J］. Transactions of the Chinese Society of Agricultural Engineering, 2018, 34(1): 22-27.
［14］　吴海志, 朱少杰, 张帆, 等. 机电式支承平台自动调平控制系统设计［J］. 山东理工大学学报(自然科学版), 2021, 35(4): 29-35.
Wu Haizhi, Zhu Shaojie, Zhang Fan,et al. Design of automatic leveling control system for electromechanical support platform ［J］. Journal of Shandong University of Technology (Natural Science Edition), 2021, 35(4): 29-35.
［15］　丁为民, 孙元昊, 赵思琪, 等. 犁旋一体机自动调平系统设计与试验［J］. 农业工程学报, 2018, 34(17): 25-31.
Ding Weimin, Sun Yuanhao, Zhao Siqi, et al. Design and test automatic leveling system of plough rotary machine ［J］. Transactions of the Chinese Society of Agricultural Engineering, 2018, 34(17): 25-31.
［16］　Sun Y, Xu L, Jing B, et al. Development of a fourpoint adjustable lifting crawler chassis and experiments in a combine harvester ［J］. Computers and Electronics in Agriculture, 173.
［17］　Lee S S, Oh K S, Hwang H, et al. Automatic leveling control system for combine ［J］. IFAC Proceedings Volumes, 2000, 33(29): 255-258.
［18］　Wang Z, Yang J,Liu P, et al. Development of an agricultural vehicle levelling system based on rapid active leveling ［J］. Biosystems Engineering, 2019, 186: 337-348.
［19］　Sun X Q, Cai Y F, Yuan C, et al. Fuzzy sliding mode control for the vehicle height and leveling adjustment system of an electronic air suspension ［J］. Chinese Journal of Mechanical Engineering, 2018.
［20］　杨腾祥. 履带式联合收割机全向调平底盘设计与试验研究［D］. 北京: 中国农业科学院, 2020.
［21］　张芳. 高精度平台调平控制系统研究［D］. 太原: 中北大学, 2008.
Zhang Fang. Study on leveling control system of high precision platform ［D］. Taiyuan: North University of China, 2008.
［22］　刘寒霜. 基于复杂环境下车载平台调平控制系统的研究［D］. 长沙: 中南林业科技大学, 2019.
Liu Hanshuang. Research on leveling control system of vehicle platform based on complex environment ［D］. Changsha: Central South University of Forestry and Technology, 2019.
［23］　梁卓. 山地履带拖拉机底盘控制系统研究［D］. 杨凌: 西北农林科技大学, 2020.
Liang Zhuo. Research on chassis control system of hillside crawler tractor ［D］. Yangling: Northwest A & F University, 2020.
［24］　Pijuan J, Cornelias M, Nogues M, et al. Active bogies and chassis levelling for a vehicle operating in rough terrain ［J］. Journal of Terramechanics, 2012, 49(3-4): 161-171.
［25］　Irsel G, Altinbalik M T. Adaptation of tilt adjustment and tracking force automation system on a lasercontrolled land leveling machine ［J］. Computers and Electronics in Agriculture, 2018, 150: 374-386.
［26］　Bashiri B, Mann D D. Automation and the situation awareness of drivers in agricultural semiautonomous vehicles ［J］. Biosystems Engineering, 2014, 124: 8-15.
［27］　刘俊, 陈无畏. 车辆电动转向系统的卡尔曼滤波模糊PID控制［J］. 农业机械学报, 2007(9): 1-5.
Liu Jun, Chen Wuwei. Study on EPS using fuzzy and PID multimode control with Kalman filter ［J］. Transactions of the Chinese Society for Agricultural Machinery, 2007(9): 1-5.
［28］　郭娜, 胡静涛. 基于Smith-模糊PID控制的变量喷药系统设计及试验［J］. 农业工程学报, 2014, 30(8): 56-64.
Guo Na, Hu Jingtao. Design and experiment of variable rate spaying system on Smithfuzzy PID control ［J］. Transactions of the Chinese Society of Agricultural Engineering, 2014, 30(8): 56-64.
［29］　杨洋, 程尚坤, 齐健, 等. 基于人机工效学的农机座椅自动调平系统设计与试验［J］. 农业机械学报, 2022, 53(6): 434-442.
Yang Yang, Cheng Shangkun, Qi Jian, et al. Design and test of automatic leveling system for agricultural machinery seat based on ergonomics ［J］. Transactions of the Chinese Society for Agricultural Machinery, 2022, 53(6): 434-442.
［30］　张波, 李杰, 刘伟, 等. 基于卡尔曼滤波的动态角度测量系统设计［J］. 电子器件, 2018, 41(2): 375-379.
Zhang Bo, Li Jie, Liu Wei, et al. Design of dynamic angle measurement system based on Kalman filter ［J］. Chinese Journal of Electron Devices, 2018, 41(2): 375-379.
［31］　仕润霖, 冯永保, 李淑智, 等. 模糊PID控制的车载平台高精度动态调平仿真研究［J］. 机床与液压, 2013, 41(5): 150-153, 74.

[1]	孙正, 薛龙, 何梁, 刘木华, 黎静, 郑建鸿. 辣椒穴盘苗自动取投苗装置设计与试验[J]. 中国农机化学报, 2023, 44(7): 48-54.
[2]	张小亮, 谢守勇, 苑晓亮, 邓成志, 刘凡一, 王鹏. 整排夹茎式穴盘苗取投苗系统设计与试验[J]. 中国农机化学报, 2023, 44(6): 42-47.
[3]	刘岗微, 倪有亮, 杨腾祥, 齐彦栋, 金诚谦. 大豆收获机割台高度自动控制系统设计与试验[J]. 中国农机化学报, 2023, 44(6): 155-160.
[4]	吴传云, 冯健, 吴俊, 李丹阳, 李曦, 舒娟, 王康军. 油菜移栽机作业效果综合测评[J]. 中国农机化学报, 2023, 44(3): 1-5.
[5]	冯莉, 吕修凯, 崔生乐, 杨春梅, 徐晓燕. 基于双向迪杰斯特拉算法移栽机补栽路径规划及仿真[J]. 中国农机化学报, 2023, 44(3): 177-182.
[6]	鲁丁, 王卫兵, 韩帅. 取苗机械手运动控制联合仿真研究及试验[J]. 中国农机化学报, 2023, 44(2): 8-13.
[7]	李洪兵, 罗洋, 张颖, 王雨凝, 欧俊, 崔浩. 基于模糊PID控制的NB-IoT果蔬农业物联网系统设计与试验[J]. 中国农机化学报, 2023, 44(1): 162-171.
[8]	张妮, 张国忠, 王姣, 李硕, 卢丽君, 董昭. 旱地作物机械化移栽关键技术研究现状与发展趋势#br# #br# [J]. 中国农机化学报, 2022, 43(8): 22-31.
[9]	谢佩军, 张育斌 . 阻尼累加离散灰色预测的Smith预估智能灌溉系统[J]. 中国农机化学报, 2022, 43(8): 158-165.
[10]	杨启志, 朱梦岚, 贾翠平, 李章彦, 何文兵, 胡建平. 穴盘苗高速移栽机吊杯式栽植器膜上成穴性能仿真与试验[J]. 中国农机化学报, 2022, 43(7): 1-7.
[11]	李加琪, 杜娟, 安广顺, 任可芸, 王中義, 印祥, . 高地隙植保机油门自动控制系统研制与试验[J]. 中国农机化学报, 2022, 43(7): 51-56.
[12]	韩长杰, 韩鸿飞, 尤佳, 芮雪, 张静, 高杰. 自动移栽机工况信息监测系统设计与试验[J]. 中国农机化学报, 2022, 43(4): 60-65.
[13]	崔迎港, 徐晓辉, 宋涛, 孙圆龙, 司玉龙. 基于SOA优化模糊PID的水肥控制系统研究[J]. 中国农机化学报, 2022, 43(3): 60-67.
[14]	徐高伟, 宋裕民, 褚瑞霞, 荐世春, 邱绪云, 高琦. 添加配重的五杆式丹参移栽机构动力学优化设计与试验[J]. 中国农机化学报, 2022, 43(2): 15-21.
[15]	刘思幸, 柴岩, 柳天虹, 李爽, 缪宏, 韩非. 基于卡尔曼滤波PID控制的精量排种器优化设计与试验[J]. 中国农机化学报, 2022, 43(11): 1-8.