大功率拖拉机悬浮前桥设计、调试与试验

doi:10.13733/j.jcam.issn.2095-5553.2024.10.024

摘要/Abstract

摘要： 针对现国产大功率拖拉机驾驶舒适性差、易驾驶疲劳、作业效率低等问题，设计一种非独立悬浮前桥，运用仿真分析、边界试验、响应试验、隔振质量试验等对其结构参数进行优化确定。按照悬浮前桥寿命15 000 h，拖拉机最高时速40 km/h，最大制动减速度5 m/s²，悬浮量±65 mm的边界，结合理论分析与经验设计，初步确定悬浮前桥刚度值310~980 N/mm，对应的无阻尼固有频率范围小于2.0 Hz；阻尼系数范围0.2~0.7 s-1；模式切换时，位置调整时间6~30 s，泄压时间小于30 s。仿真分析与边界试验的结果表明：悬浮前桥满足15 000 h寿命要求，满足40 km/h最高时速，最大制动减速度5 m/s²的使用需求。经响应试验验证及优化，模式切换时，位置调整时间为3.57~14.71 s，泄压时间小于16.69 s。隔振质量试验表明，无阻尼固有频率小于1.8 Hz，阻尼系数0.45~0.56 s-1。

关键词: 悬浮前桥, 拖拉机, 独立侧最小加速度, 振动谱, 傅里叶变换

Abstract: In view of the problems of poor driving comfort, easy driving fatigue and low working efficiency of the domestic high‑horsepower tractor, a non‑independent suspension front axle is designed, the structural parameters are optimized and determined by simulation analysis, boundary test, response test and vibration isolation quality test. According to the boundary of suspension front axle life of 15 000 hours, tractor maximum speed of 40 km/h, maximum braking deceleration of 5 m/s², suspension capacity of ±65 mm, combined with theoretical analysis and empirical design, the stiffness value of the suspension front axle is initially determined to be 310-980 N/mm, and the corresponding undamped natural frequency range is less than 2.0 Hz. The damping coefficient range is 0.2-0.7 s-1. When the mode is switched, the position adjustment time is 6-30 s, and the pressure relief time is less than 30 s. The results of simulation analysis and boundary test show that the suspension front axle meets the life requirement of 15 000 hours, the maximum speed of 40 km/h and the maximum braking deceleration of 5 m/s². After the response test and optimization, the position adjustment time is 3.57-14.71 s and the pressure relief time is less than 16.69 s when the mode is switched. The vibration isolation quality test shows that the undamped natural frequency is less than1.8 Hz, and the damping coefficient is 0.45-0.56 s-1.

Key words: , suspension front axle, tractor, independent side minimum acceleration, vibration spectrum, Fourier transform

中图分类号:

S232.3
S24

赵文科, 付帅, 张丽媛, 董云蓬, 贾强, 朱昊. 大功率拖拉机悬浮前桥设计、调试与试验[J]. 中国农机化学报, 2024, 45(10): 162-169.

Zhao Wenke, Fu Shuai, Zhang Liyuan, Dong Yunpeng, Jia Qiang, Zhu Hao. Design, commissioning and test of suspension front axle of high‑power tractor[J]. Journal of Chinese Agricultural Mechanization, 2024, 45(10): 162-169.

参考文献

[ 1 ] 武辉, 张传龙. 国内拖拉机转向驱动桥现状和发展趋势[J]. 拖拉机与农用运输车, 2011, 38(6): 18-19, 23.
[ 2 ] 马然, 朱思洪, Cuong D M. 拖拉机前桥半主动悬架特性参数匹配与控制[J]. 农业机械学报, 2013, 44(12): 6-10.
Ma Ran, Zhu Sihong, Cuong D M. Parameters matching and control of tractor front axle semi‑active suspension [J]. Transactions of the Chinese Society for Agricultural Machinery, 2013, 44(12): 6-10.
[ 3 ] 裴志影. 农业拖拉机技术的发展研究[J]. 民营科技, 2015(4): 37.
[ 4 ] 赵剡水, 杨为民. 农业拖拉机技术发展观察[J]. 农业机械学报, 2010, 41(6): 42-48.
Zhao Yanshui, Yang Weimin. Technological development of agricultural tractor [J]. Transactions of the Chinese Society for Agricultural Machinery, 2010, 41(6): 42-48.
[ 5 ] 文爱民, 吴俊淦, 刘奕贯, 等. 拖拉机线控液压转向路感控制策略研究[J]. 中国农机化学报, 2015, 36(6): 156-159, 183.
Wen Aimin, Wu Jungan, Liu Yiguan, et al. Study on road feeling control strategy of tractor hydraulic steering by‑wire system [J]. Journal of Chinese Agricultural Mechanization, 2015, 36(6): 156-159, 183.
[ 6 ] Scarlett A J, Price J S, Stayner R M. Whole‑body vibration: Evaluation of emission and exposure levels arising from agricultural tractors [J]. Journal of Terramechanics, 2006, 44(1): 65-73.
[ 7 ] 伊力达尔 ⋅ 伊力亚斯, 朱恩洪, 徐刚, 等. 拖拉机前桥悬架参数匹配及其对振动特性的影响[J]. 农业工程学报, 2015, 31(10): 29-36.
Yilidaer ⋅ Yiliyasi, Zhu Sihong, Xu Gang, et al. Front axle suspension parameters match and its impact on vibration characteristics of tractor [J]. Transactions of the Chinese Society of Agricultural Engineering, 2015, 31 (10): 29-36.
[ 8 ] 管春松, 胡桧, 陈永生, 等. 温室用小型电动拖拉机研究[J]. 中国农机化学报, 2015, 36(2): 67-69, 76.
Guan Chunsong, Hu Hui, Chen Yongsheng, et al. Study on small electric tractors for greenhouse [J]. Journal of Chinese Agricultural Mechanization, 2015, 36(2): 67-69, 76.
[ 9 ] 申仲翰, 黄清华, 祝发荣, 等. 运输车辆振动环境与人体响应的监测研究[J]. 振动与冲击, 2001, 20(1): 9-11, 92.
[10] 薛晶, 侯占峰, 闫建国, 等. 小型轮式拖拉机噪声控制研究[J]. 中国农机化学报, 2015, 36(5): 212-214.
Xue Jing, Hou Zhanfeng, Yan Jianguo, et al. Noise control of small wheel tractor [J]. Journal of Chinese Agricultural Mechanization, 2015, 36(5): 212-214.
[11] 赵国栋, 管春松, 肖体琼, 等. 拖拉机电动悬挂机构性能分析及参数优化[J]. 中国农机化学报, 2019, 40(3): 122-127.
Zhao Guodong, Guan Chunsong, Xiao Tiqiong, et al. Performance analysis and parameter optimization of tractor electric suspenxion mechanism [J]. Journal of Chinese Agricultural Mechanization, 2019, 40 (3): 122-127.
[12] 刘学峰, 张德学, 张成保, 等. 重型拖拉机全独立式悬浮转向驱动桥液压系统设计研究[J]. 中国农机化学报, 2020, 41(10): 99-103, 110.
Liu Xuefeng, Zhang Dexue, Zhang Chengbao, et al. Design and research on hydraulic system of fully independent and suspended steering axle for heavy tractor [J]. Journal of Chinese Agricultural Mechanization, 2020, 41(10): 99-103, 110.
[13] 张翠英, 仪垂良, 刘学峰, 等. 基于CAN总线的悬浮式转向驱动桥电气控制系统设计[J]. 农业装备与车辆工程, 2021, 59(5): 1-5.
Zhang Cuiying, Yi Chuiliang, Liu Xuefeng, et al. Design of electric control system for suspended steering drive axle based on CAN [J]. Agricultural Equipment & Vehicle Engineering, 2021, 59(5): 1-5.
[14] 顾进恒, 傅生辉, 刘长卿, 等. 大功率拖拉机悬浮式前桥悬架插装式比例阀建模与设计[J]. 农业机械学报, 2020, 51(1): 542-549.
Gu Jinheng, Fu Shenghui, Liu Changqing, et al. Modeling and design of cartridge proportional valve of front axle suspension for high‑power wheeled tractor [J]. Transactions of the Chinese Society for Agricultural Machinery, 2020, 51(1): 542-549.
[15] Karl T R. Fundamentals of tractor design [M]. Springer Nature Switzerland and AG, 2020.
[16] Slaski, G. Damping parameters of suspension of passenger vehicle equipped with semi‑active dampers with by‑pass valve [J]. Transport Problems, 2011, 6(2): 35-42.
[17] Wolfgang B. Hydropneumatic suspension systems [M]. Springer-Verlag GmbH Germany, part of Springer Nature, 2022.
[18] 伊力达尔 ⋅ 伊力亚斯. 前桥悬架对拖拉机振动特性的影响[D]. 南京: 南京农业大学, 2015.
[19] 袁加奇, 朱思洪, 高强, 等. 拖拉机前桥油气弹簧的设计与特性研究[J]. 南京农业大学学报, 2017, 40(1): 176-185.
Yuan Jiaqi，Zhu Sihong，Gao Qiang, et al. Design and characteristic study of tractor front axle hydro‑pneumatic spring [J]. Journal of Nanjing Agricultural University, 2017, 40(1): 176-185.
[20] 刘洪鹏, 唐国强. CAN总线负载率算法及优化设计[J]. 客车技术与研究, 2019(5): 31-33.
Liu Hongpeng, Tang Guoqiang. Algorithm and optimization design of CAN bus load rate [J]. Bus & Coach Technology and Research, 2019 (5): 31-33.

[1]	李玲玲, 李广宇, 徐峰, 王华泽, 高瑞遥, 张煜晗. 丘陵山地拖拉机坡地自适应控制系统仿真分析与试验[J]. 中国农机化学报, 2024, 45(9): 141-146.
[2]	闫祥海, 闫宇翔, 张俊江, 王伟, 徐立友, . 基于自适应阈值优化的插电并联式混合动力拖拉机节能控制研究[J]. 中国农机化学报, 2024, 45(9): 147-152.
[3]	李伟 , 张秀梅 , 邵明玺 . 丘陵山地拖拉机悬挂液压集成阀块结构参数设计及优化[J]. 中国农机化学报, 2024, 45(9): 153-158.
[4]	杨俊茹, 于小东, 李瑞川, 徐继康, 韩宗冉, 李艳超, . 拖拉机多路阀节流槽动态特性研究与试验[J]. 中国农机化学报, 2024, 45(8): 126-131.
[5]	邵明玺, 张秀梅, 李伟. 先导式节流阀比例电磁铁参数设计及优化[J]. 中国农机化学报, 2024, 45(7): 152-159.
[6]	毛恩荣, 王皓洁, 杜岳峰, 朱忠祥, 翟志强, 张丽榕. 大功率拖拉机多工况换挡自适应控制策略[J]. 中国农机化学报, 2024, 45(5): 122-127.
[7]	王顺, 马心坦, 贺明佳. 拖拉机驾驶室内低频噪声控制研究[J]. 中国农机化学报, 2024, 45(5): 134-139.
[8]	张九通, 唐维东, 刘鸿瑞, 杨思存, 廖明亮, 蒋猛. 基于RFID与GPS的拖拉机机库信息管理系统的设计与开发[J]. 中国农机化学报, 2024, 45(5): 154-160.
[9]	魏国俊, 王鸿翔, 王圣杰, 王振雨, 肖茂华. 基于CKF的大型拖拉机状态参数估计研究[J]. 中国农机化学报, 2024, 45(4): 117-122.
[10]	祝贺, 戚彬, 李衍豪, 赵树行, 王莉. 基于主客观组合加权法的拖拉机座椅舒适度评价[J]. 中国农机化学报, 2024, 45(3): 140-147.
[11]	吐尔逊·买买提, 谢海巍, 孔庆好, 陈俊豪, 马洁, 曲古拉·图马尔拜. 农用拖拉机不同工况下排放特性[J]. 中国农机化学报, 2024, 45(2): 164-172.
[12]	李仲兴, 朱方喜, 刘炳晨, 郗少华. 基于改进PSO-BPNN的拖拉机液压油品质监测[J]. 中国农机化学报, 2024, 45(10): 140-146.
[13]	缪皓楠, 尹必峰, 黄幼林, 朱亚辉, 解玄, 恽龙. 基于动态规划算法的串联式混合动力拖拉机犁耕工况能量管理研究[J]. 中国农机化学报, 2024, 45(10): 147-153.
[14]	徐钊睿, 赵业慧, 刘风平, 薛丽君, 杨延强, 王光明, . 拖拉机液压功率分流无级变速箱设计[J]. 中国农机化学报, 2024, 45(1): 138-143.
[15]	廖青, 黑晓涛, 侯炳坤, 张超, . 船式拖拉机驾驶室低频噪声研究[J]. 中国农机化学报, 2023, 44(9): 117-122.