PODE、DMC掺混柴油的燃烧及排放特性对比研究

doi:10.13733/j.jcam.issn.2095‑5553.2025.02.023

摘要/Abstract

摘要： 为对比柴油机掺混不同的含氧燃料时，不同碳氧键燃料对燃烧及排放特性的差异性影响,以柴油（Diesel）、聚甲氧基二甲醚（PODE）/柴油、碳酸二甲酯（DMC）/柴油为对象，在高压共轨柴油机上，考察其在不同预喷比例及废气再循环（EGR）率下的燃烧及排放特性规律。结果表明：碳氧单键含氧燃料降低碳烟能力比碳氧双键含氧燃料更强，随着EGR率增加，PODE/Diesel的放热率峰值变化幅度更大，NOX排放大幅下降，EGR率为20%时，PODE/Diesel与DMC/Diesel的烟度分别下降78.10%、40.93%；随着预喷比例增加，DMC/Diesel放热率峰值变化幅度更大，NOX排放有所下降，预喷比例为20%时，PODE/Diesel与DMC/Diesel的烟度下降64.27%、43.40%；3种燃料中，碳氧单键混合燃料的核态颗粒物数量浓度峰值最高，但颗粒物几何平均粒径最低。

关键词: 含氧燃料, 废气再循环, 预喷策略, 柴油机

Abstract: In order to compare the differential effects of different carbon‑oxygen bond fuels on combustion and emission characteristics when diesel engines are mixed with different oxygen‑containing fuels, diesel, polymethoxy dimethyl ether (PODE)/Diesel, and dimethyl carbonate (DMC)/Diesel were employed to investigate the combustion and emission characteristics of high‑pressure common rail diesel engines under various pre‑injection ratios and exhaust gas recirculation (EGR) rates. The results demonstrated that carbon‑oxygen single bond oxygen‑containing fuel had a stronger ability to reduce carbon smoke than carbon‑oxygen double bond oxygen‑containing fuel. With an increase in the EGR rate, the peak change in the heat release rate of PODE/Diesel was greater, leading to a significant reduction in NOX emissions. At an EGR rate of 20%, the smoke levels of PODE/Diesel and DMC/Diesel decreased by 78.10% and 40.93%, respectively. Similarly, as the pre‑spray ratio increased, the peak change in heat release rate of DMC/Diesel was greater, and NOX emissions decreased. At a pre‑spray ratio of 20%, the smoke levels of PODE/Diesel and DMC/Diesel decreased by 64.27% and 43.40%, respectively. Among the three fuels, the peak concentration of nuclear particulate matter in the carbon‑oxygen single bond hybrid fuel was the highest, but the geometric average particle size of the particulate matter was the lowest.

Key words: , oxygenated fuel, exhaust gas recirculation, pilot injection strategy, diesel engines

中图分类号:

S219
TK421

周斌, 尹川, 蒋状, 曾东建, 韩伟强, 蒲俊州. PODE、DMC掺混柴油的燃烧及排放特性对比研究[J]. 中国农机化学报, 2025, 46(2): 153-159.

Zhou Bin, Yin Chuan, Jiang Zhuang, Zeng Dongjian, Han Weiqiang, Pu Junzhou. Comparative study on the combustion and emission characteristics of PODE and DMC blended diesel fuel [J]. Journal of Chinese Agricultural Mechanization, 2025, 46(2): 153-159.

参考文献

[ 1 ] Johnson T V . Review of vehicular emissions trends [J]. SAE International Journal of Engines, 2015, 8(3): 1152-1167.
[ 2 ] 刘浩, 刘志强, 张学东, 等. 柴油机工作过程模拟及进气相位优化[J]. 中国农机化学报, 2016, 37(3): 167-171.
Liu Hao, Liu Zhiqiang, Zhang Xuedong, et al. Working process simulation on diesel engine and optimization on value timing [J]. Journal of Chinese Agricultural Mechanization, 2016, 37 (3): 167-171.
[ 3 ] Qi D, Ma L, Chen R, et al. Effects of egr rate on the combustion and emission characteristics of diesel‑palm oil‑ethanol ternary blends used in a crdi diesel engine with double injection strategy [J]. Applied Thermal Engineering, 2021, 199: 117530.
[ 4 ] 李思远. 重型柴油机低温均质引燃燃烧与排放特性的试验研究[D]. 济南：山东大学, 2016.
[ 5 ] Qian Y, Wang X, Zhu L, et al. Experimental studies on combustion and emissions of RCCI (reactivity controlled compression ignition) with gasoline/n‑heptane and ethanol/n‑heptane as fuels [J]. Energy, 2015, 88(8): 584-594.
[ 6 ] Wang Z, Liu H Y, Ma X, et al. Homogeneous charge compression ignition (HCCI) combustion of polyoxymethylene dimethyl ethers (PODE)[J]. Fuel, 2016, 183(11): 206-213.
[ 7 ] Duan H, Jia M, Chang Y, et al. Experimental study on the influence of low‑temperature combustion (LTC) mode and fuel properties on cyclic variations in a compression‑ignition engine [J]. Fuel, 2019, 256: 115907.
[ 8 ] 吴长贵, 周俊冬, 钱勇, 等. 脂肪酸甲酯/柴油二元混合燃料低温燃烧模式下的燃烧试验[J]. 南通职业大学学报, 2020, 34(2): 84-89.
[ 9 ] 王贵勇, 詹益嘉, 申立中, 等. 高海拔下预喷策略对甲醇/柴油双燃料发动机燃烧与排放特性的影响[J]. 昆明理工大学学报(自然科学版), 2023, 48(2): 73-86.
Wang Guiyong, Zhan Yijia, Shen Lizhong, et al. Effects of pre‑injection parameters on combustion and emissions of an methanol /diesel dual fuel engine at high altitude [J]. Journal of Kunming University of Science and Technology (Natural Science) , 2023, 48(2): 73-86.
[10] Pan M, Wang Y, Qian W, et al. Experimental and numerical study on flow, combustion and emission characteristics of CI engine fueled with n‑butanol/diesel blends under post‑injection strategy [J]. Fuel, 2021, 292: 120267.
[11] Liu J, Liu Z, Wang L, et al. Effects of PODE/diesel blends on particulate matter emission and particle oxidation characteristics of a common‑rail diesel engine [J]. Fuel Processing Technology, 2021, 212: 106634.
[12] Kumar B R, Saravanan S. Partially premixed low temperature combustion using dimethyl carbonate (DMC) in a DI diesel engine for favorable smoke/NOX emissions [J]. Fuel, 2016, 180: 396-406.
[13] Lin Q, Tay L, Yu W, et al. Effects of polyoxymethylene dimethyl ether 3 (pode 3) addition and injection pressure on combustion performance and particle size distributions in a diesel engine [J]. Fuel, 2021, 283: 119347.
[14] 张韡. 碳酸二甲酯对柴油机排放特性的影响[J]. 化学工程, 2009, 37(8): 59-62.
[15] Pan M, Qian W, Zheng Z, et al. The potential of dimethyl carbonate (DMC) as an alternative fuel for compression ignition engines with different egr rates [J]. Fuel, 2019, 257: 115920.
[16] 梅德清, 任华, 姜士阳, 等. DMC/柴油混合燃料共轨柴油机燃烧循环变动研究[J]. 农业机械学报, 2014, 45(8): 14-18.
Mei Deqing, Ren Hua, Jiang Shiyang, et al. Combustion cyclic variations of common‑rail diesel engine fueled with DMC /diesel blend [J]. Transactions of the Chinese Society for Agricultural Machinery, 2014, 45 (8): 14-18.
[17] Chan J, Tsolakis A, Herreros J, et al. Combustion, gaseous emissions and PM characteristics of DI‑methyl carbonate (DMC)‑gasoline blend on gasoline direct injection (GDI) engine [J]. Fuel, 2020, 263: 116742.
[18] Wang X, Cheung C, Di Y, et al. Diesel engine gaseous and particle emissions fueled with diesel‑oxygenate blends [J]. Fuel, 2012, 94: 317-323.
[19] 陶冠臻. PODE煤基燃料对柴油机的燃烧与排放特性研究[J]. 应用能源技术, 2020(12): 16-23.
[20] Qi D, Ma L, Chen R, et al. Effects of egr rate on the combustion and emission characteristics of diesel‑palm oil‑ethanol ternary blends used in a crdi diesel engine with double injection strategy [J]. Applied Thermal Engineering, 2021, 199: 117530.
[21] 韩志玉, 周庭波, 陈征, 等. 基于废气再循环的丁醇/柴油混合燃料的燃烧特性[J]. 燃烧科学与技术, 2013, 19(1): 37-42.
Han Zhiyu, Zhou Tingbo, Chen Zheng, et al. Combustion characteristics of butanol‑diesel blend fuel based on EGR [J]. Journal of Combustion Science and Technology, 2013, 19(1): 37-42.
[22] Liang J, Zhang Q, Chen Z, et al. The combustion and emission characteristics of diesel‑ethanol blends with THF as cosolvents in a diesel engine operating with EGR [J]. Fuel, 2021, 298: 120843.
[23] 徐通模, 惠世恩, 周屈兰, 等. 燃烧学第2版[M]. 北京: 机械工业出版社, 2019.
[24] 卢文健. DMC/柴油混合燃料对柴油机排气颗粒物理化特性影响研究[D]. 合肥: 合肥工业大学, 2021.
[25] 陈晖, 黄豪中, 黄荣, 等. PODE掺混和喷油参数对柴油机燃烧排放特性影响[J]. 内燃机学报, 2019, 37(1): 9-16.

[1]	孟浩东, 张忠, 徐年尧, 王勇, 邹灵浩. 农用单缸柴油机油箱动态特性识别研究[J]. 中国农机化学报, 2024, 45(5): 128-133.
[2]	范梦元, 杜慧勇, 李民, 谢俊杰, 王站成, 苗家轩. 配气机构对柴油机前端噪声贡献度评价方法的试验研究[J]. 中国农机化学报, 2023, 44(8): 141-147.
[3]	薛晶, 梁运达, 刘宜坤, 杨怀誉, 宣传忠. 农用柴油机供油道除气机构设计[J]. 中国农机化学报, 2023, 44(6): 120-126.
[4]	孟浩东, 赵景波, 王勇, 郭炎, 戴旭东, 徐年尧. 农用柴油机齿轮室盖结构动态特性分析与改进[J]. 中国农机化学报, 2023, 44(11): 87-92.
[5]	徐萌, 王俊, 文奕钧, 史志鹏, 王坤. 小型农用柴油机油耗和排放的多目标优化[J]. 中国农机化学报, 2022, 43(2): 112-120.
[6]	张美娟, 陈梓含, 王忠, 陈晟闽. 农用单缸柴油机喷醇器流量特性试验研究[J]. 中国农机化学报, 2022, 43(12): 99-105.
[7]	郭俊;杨国伟;沈文龙;刘玮;. 基于Nastran农用EV80型二缸柴油机曲轴性能分析[J]. 中国农机化学报, 2021, 42(2): 121-127.
[8]	程艳;. POC、DOC对农用柴油机气体排放的影响分析[J]. 中国农机化学报, 2019, 40(9): 141-145+210.