纳米SiO2—淀粉—PVA复合膜材料的制备及其在炭基肥中的应用

doi:10.13733/j.jcam.issn.20955553.2022.01.030

摘要/Abstract

摘要： 淀粉—聚乙烯醇(polyvinyl alcohol，PVA)作为缓释肥包膜材料具有价格低廉、环保等优点，但其高吸水性限制其应用，采用纳米二氧化硅(SiO2)改性可提高其疏水性。首先探讨PVA浓度、交联剂用量、增塑剂用量对淀粉—PVA复合膜吸水率的影响，之后用纳米SiO2对淀粉—PVA复合膜进行改性，探讨纳米SiO2添加量对复合膜吸水率和力学性能的影响，并找出最优原料配比，最后将此复合膜液作为黏结剂，制备生物质炭基肥并进行土柱淋溶试验。试验结果表明：在150 mL蒸馏水中控制淀粉与PVA的添加质量之和为10 g，当淀粉与PVA的质量之比为2∶3、交联剂硼砂添加量为0.1 g、增塑剂甘油添加量为3 mL时，所制成复合膜的吸水率最低，为78%。添加纳米SiO2后，各处理膜的吸水率随纳米SiO2添加量的增加呈现先升高后降低的变化，当纳米SiO2添加量为2.4 g时，与未添加的相比，复合膜的吸水率下降384%，水接触角提高89.5%，拉伸强度提高49.0%，此时制备的复合膜材料性能最佳。将纳米SiO2—淀粉—PVA复合膜材料应用于生物质炭基肥的制备，制备出的炭基肥颗粒包覆完整，粒径主要分布在3.8~4.4 mm之间，在28 d时氮素累计释放率为65%，具有良好的缓释效果，为炭基肥的开发应用提供新途径。

关键词: 纳米二氧化硅, 生物质炭, 炭基肥, 复合膜材料, 缓释性能

Abstract: Starchpolyvinyl alcohol (PVA) as a slowrelease fertilizer coating material has the advantages of low price and environmental protection, but its high water absorption limits its application. The use of nanosilica (SiO2) can improve its hydrophobicity. This article first discussed the influence of PVA concentration, crosslinking agent dosage, and plasticizer dosage on the water absorption of starchPVA composite film, then modified the starchPVA composite film with nanoSiO2, explored the effect of nanoSiO2 addition on the water absorption of the composite film, found out the optimal ratio of raw materials, and finally, used the composite membrane liquid as a binder to prepare biomass carbonbased fertilizer. The test results show that when the sum of the added mass of starch and PVA in 150 mL of distilled water is controlled to be 10 g, the mass ratio of starch to PVA is 2∶3, 0.1 g of crosslinking agent borax is added, and 3 mL of plasticizer glycerin is added, the water absorption rate of the composite membrane made is the lowest at 78%. After adding nanoSiO2, the water absorption rate of each treatment film increased first and then decreased with the increase of nanoSiO2 addition amount. When the addition amount of nanoSiO2 was 2.4 g, the water absorption rate of the composite film decreased 38.4%compared with that without addition, the water contact angle increased by 89.5%, and the tensile strength increased by 49.0%. The composite membrane material prepared at this time has the best performance. The nanoSiO2starchPVA composite film material is applied to the preparation of biomass carbonbased fertilizer. The prepared carbonbased fertilizer particles are completely coated, and the particle size is mainly distributed between 3.8 and 4.4 mm. The cumulative nitrogen release rate at 28 d is 65%. It has a good slowrelease effect and provides a new way for the development and application of carbonbased fertilizers.

Key words: NanoSiO2, biomass char, carbonbased fertilizer, composite membrane material, slowrelease performance

中图分类号:

S24: TP271

徐佳锋, 陆嘉俊, 韩伟胜, 汤文涛, 赵超. 纳米SiO2—淀粉—PVA复合膜材料的制备及其在炭基肥中的应用[J]. 中国农机化学报, 2022, 43(1): 219-227.

Xu Jiafeng, Lu Jiajun, Han Weisheng, Tang Wentao, Zhao Chao. . Preparation of nanoSiO2starchpolyvinyl alcohol composite membrane material and its application in carbonbased fertilizer[J]. Journal of Chinese Agricultural Mechanization, 2022, 43(1): 219-227.

参考文献

［１］　张民, 杨越超, 宋付朋, 等. 包膜控释肥料研究与产业化开发［J］. 化肥工业, 2005, 32(2): 7-13.
Zhang Min, Yang Yuechao, Song Fuan, et al. Study and industrialized development of coated controlled release fertilizers ［J］. Journal of the Chemical Fertilizer Industry, 2005, 32(2): 7-13.
［2］　沈秀丽, 柳思远, 沈玉君, 等. 不同粒径生物炭包膜尿素缓释肥性能及缓释效果［J］. 农业工程学报, 2020, 36(15): 159-166.
Shen Xiuli, Liu Siyuan, Shen Yujun, et al. Property and slowrelease effect of coated urea with different particlesize biochar ［J］. Transactions of the Chinese Society of Agricultural Engineering, 2020, 36(15): 159-166.
［3］　Beig B, Niazi M, Jahan Z, et al. Coating materials for slow release of nitrogen from urea fertilizer: A review ［J］. Journal of Plant Nutrition, 2020, 43(6): 1-24.
［4］　张磊, 张根林, 鲁建江, 等. 羧甲基纤维素钠—改性膨润土复合凝胶的制备及缓释性能［J］. 西北农业学报, 2012, 21(1): 161-164.
Zhang Lei, Zhang Yinjiang, Lu Jianjiang, et al. Preparation of carboxyl methyl cellulose, modified bentonite blend gel beads and their performance on slow release of fertilizer ［J］. Acta Agriculturae Borealioccidentalis Sinica, 2012, 21(1): 161-164.
［5］　司友斌, 王慎强, 陈怀满. 农田氮、磷的流失与水体富营养化［J］. 土壤, 2000, 32(4): 188-193.
Si Youbin, Wang Shenqiang, Chen Huaiman. Water eutrophication and losses of nitrogen and phosphates in farmland ［J］. Soils, 2000, 32(4): 188-193.
［6］　Nancy T. Determination of nitrogen, phosphorus, and potassium release rates of slowand controlledrelease fertilizers: singlelaboratory validation, first action 2015.15 ［J］. Journal of Aoac International, 2016, 99(2): 353-359.
［7］　何刚, 张崇玉, 王玺, 等. 包膜缓释肥料的研究进展及发展前景［J］. 贵州农业科学, 2010, 38(6): 141-145.
He Gang, Zhang Chongyu, Wang Xi, et al. Research progress and development prospect of coated slowrelease fertilizer ［J］. Guizhou Agricultural Sciences, 2010, 38(6): 141-145.
［8］　乔迁, 王树江, 姜宇航, 等. 淀粉/聚乙烯醇包覆尿素膜的制备及其性能［J］. 长春工业大学学报(自然科学版), 2012, 33(5): 575-578.
Qiao Qian, Wang Shujiang, Jiang Yuhang, et al. Preparation and properties of starch/polyvinyl alcohol membrane coated urea ［J］. Journal of Changchun University of Technology (Natural Science Edition), 2012, 33(5): 575-578.
［9］　金书秦, 张惠, 唐佳丽. 化肥使用量零增长实施进展及“十四五”减量目标和路径［J］. 南京工业大学学报(社会科学版), 2020, 19(3): 66-74.
［10］　白杨. 纳米SiO2—聚乙烯醇—γ-聚谷氨酸复合物包膜肥料研制及其养分缓释机理［D］. 沈阳: 沈阳农业大学, 2020.
Bai Yang. Manufacture of NanoSiO2-Polyvinyl alcohol-γ-glutamic acid composite coated fertilizer and its nutrient slow and release mechanism ［D］. Shenyang: Shenyang Agricultural University, 2020.
［11］　陈志周, 王洁琛, 马倩云, 等. 纳米SiO2超声分散条件对复合薄膜性能的影响［J］. 包装工程, 2020, 41(17): 85-90.
Chen Zhizhou, Wang Jiechen, Ma Qianyun, et al. Influence of NanoSiO2 ultrasonic dispersion conditions on the properties of composite films ［J］. Packaging Engineering, 2020, 41(17): 85-90.
［12］　徐国鑫, 王子芳, 高明, 等. 秸秆与生物炭还田对土壤团聚体及固碳特征的影响［J］. 环境科学, 2018, 39(1): 355-362.
Xu Guoxin, Wang Zifang, Gao Ming, et al. Effects of straw and biochar return in soil on soil aggregate and carbon sequestration ［J］. Environmental Science, 2018, 39(1): 355-362.
［13］　李贞霞, 任秀娟, 祁雪娇, 等. 辣椒秸秆生物炭对酸化土壤交换性能及酶活性的影响［J］. 西北农业学报, 2019, 28(1): 117-124.
Li Zhenxia, Ren Xiujuan, Qi Xuejiao, et al. Effect of chili straw biochar for the exchangeable property and enzyme activity of acidified soil ［J］. Acta Agriculturae Borealioccidentalis Sinica, 2019, 28(1): 117-124.
［14］　唐司尘, 杨肖松, 张万通, 等. 鸟粪石及生物炭包膜缓释肥在石灰性土壤中的氮磷释放特性［J］. 中国科学院大学学报, 2021, 38(1): 83-93.
Tang Sichen, Yang Xiaosong, Zhang Wantong, et al. Characteristics of nitrogen and phosphorus release from struvite coated urea and struvite combined with biochar coated urea in calcareous soil ［J］. Journal of University of Chinese Academy of Sciences, 2021, 38(1): 83-93.
［15］　李倩文, 杜聪. 纳米二氧化硅改性聚乙烯醇/淀粉复合膜的制备及性能研究［J］. 食品科技, 2018, 43(3): 74-79.
Li Qianwen, Du Cong. Preparation and properties of nanoSiO2 modified PVA/starch composite membrane ［J］. Food Science and Technology, 2018, 43(3): 74-79.
［16］　白杨, 陈松岭, 范丽娟, 等. 纳米SiO2—聚乙烯醇—γ聚谷氨酸复合膜材料制备及其性能研究［J］. 植物营养与肥料学报, 2019, 25(12): 2044-2052.
Bai Yang, Chen Songling, Fan Lijuan, et al. Preparation and properties of nanoSiO2—polyvinyl alcohol—γpolyglutamic acid composite film materials ［J］. Plant Nutrition and Fertilizer Science, 2019, 25(12): 2044-2052.
［17］　陈松岭, 蒋一飞, 巴闯, 等. 生物改性聚乙烯醇可降解包膜材料的特征及其光谱特性［J］. 中国土壤与肥料, 2017(4): 154-160.
Chen Songlin, Jiang Yifei, Ba Chuang, et al. Characteristics and spectral characteristics of biomodified polyvinyl alcohol degradable coating materials ［J］. Soils and Fertilizers Sciences in China, 2017(4): 154-160.
［18］　赵媛, 严文静, 赵见营, 等. 柠檬醛/纳米SiO2交联改性PVA复合材料阻水性能和结构研究［J］. 食品工业科技, 2019, 40(17): 148-153, 160.
Zhao Yuan, Yan Wenjing, Zhao Jianying, et al. Water resistance and structure of PVA composite membrane modified by citral and nanoSiO2 crosslinking ［J］. Science and Technology of Food Industry, 2019, 40(17): 148-153, 160.
［19］　赵美贺. 改性膨润土/聚氨酯复合材料的制备及其在包膜缓释肥中的应用［D］. 广州: 华南农业大学, 2017.
Zhao Meihe. Study on synthesis and modified bentonite/polyurethane composite for slow release fertilizer ［D］. Guangzhou: South China Agricultural University, 2017.
［20］　周建军. 流化床制备包衣尿素微球的工艺研究［D］. 郑州: 郑州大学, 2019.
Zhou Jianjun. Studies on the preparation of coated urea microspheres by fluidized bed ［D］. Zhengzhou: Zhengzhou University, 2019.
［21］　王超, 杨子明, 焦静, 等. 包膜控释肥及其膜材的研究进展［J］. 高分子通报, 2020(9): 37-42.
Wang Chao, Yang Ziming, Jiao Jing, et al. A review of controlled release fertilizer and coating materials ［J］. Chinese Polymer Bulletin, 2020(9): 37-42.
［22］　李旭. 淀粉—聚乙烯醇—膨润土包膜尿素缓释肥料的制备及性能研究［D］. 长春: 吉林大学, 2016.
Li Xu. Preparation and properties of starchpolyvinyl alcoholbentonite coated urea slowrelease fertilizer ［D］. Changchun: Jilin University, 2016.
［23］　刘晓菲, 程春生, 覃宇悦, 等. 增塑剂对壳聚糖/纳米蒙脱土复合膜物理性能的影响［J］. 食品与发酵工业, 2011, 37(2): 87-90.
Liu Xiaofei, Cheng Chunsheng, Tan Yuyue, et al. Effect of plasticizer on properties of chitosan/nanomontmorillonite composited film ［J］. Food and Fermentation Industries, 2011, 37(2): 87-90.
［24］　胡安, 高桂枝, 朱伟, 等. 硼砂尿素复合改性聚乙烯醇制备可降解包装材料［J］. 塑料, 2013, 42(3): 103-105.
Hu An, Gao Guizhi, Zhu Wei, et al. Preparation of modified PVA biodegradable packaging materials by borax and urea ［J］. Plastics, 2013, 42(3): 103-105.
［25］　李彦明, 刘晓霞, 李国学, 等. 淀粉粘结剂在有机复混肥造粒中的应用［J］. 中国生态农业学报, 2007, 15(3): 29-31.
Li Yanming, Liu Xiaoxia, Li Guoxue, et al. Application of starch adhesive in organic compound fertilizer granulation ［J］. Chinese Journal of EcoAgriculture, 2007, 15(3): 29-31.
［26］　薛朝臣. 可生物降解缓释肥包膜材料的制备与性能研究［D］. 合肥: 合肥工业大学, 2017.
Xue Chaocheng. Preparation and properties of biodegradable coating materials for slow release fertilizers ［D］. Hefei: Hefei University of Technology, 2017.
［27］　陈芝, 杨相东, 王娜, 等. 肥料缓释用改性SiO2/PU复合涂层的制备与表征［J］. 化工新型材料, 2020, 48(10): 146-150.
Chen Zhi, Yang Xiangdong, Wang Na, er al. Preparation and characterization of modified SiO2/PU composite coating for controlledrelease fertilizer ［J］. New Chemical Materials, 2020, 48(10): 146-150.
［28］　马霞, 李路遥, 张缅缅, 等. pH敏感γ—聚谷氨酸/聚乙烯醇水凝胶的溶胀动力学［J］. 农业工程学报, 2016, 32(S1): 333-338.
Ma Xia, Li Luyao, Zhang Mianmian, et al. Study on hydrogels of swelling kinetics of pHsensitiveγPGA/PVA ［J］. Transactions of the Chinese Society of Agricultural Engineering, 2016, 32(S1): 333-338.
［29］　陈秀宇, 陈国奋. 纳米SiO2改性PVA/可溶性淀粉复合膜的研究［J］. 江汉大学学报(自然科学版), 2020, 48(04): 5-10.
Chen Xiuyu, Chen Guofen. Study on PVA/Soluble starch composite film modified by NanoSiO2 ［J］. Journal of Jianghan University (Natural Science Edition), 2020, 48(4): 5-10.
［30］　侯婷. 玉米醇溶蛋白/纳米二氧化硅复合膜的超声波制备技术研究［D］. 镇江: 江苏大学, 2020.
Hou Ting. Study on ultrasonic preparation technology of Zein/Nanosilica composite film ［D］. Zhenjiang: Jiangsu University, 2020.
［31］　刘瑶, 章建浩, 龙门, 等. 硼砂协同纳米SiO2、TiO2交联改性PVA基膜材料及其透湿和抑菌性分析［J］. 食品科学, 2014, 35(14): 17-23.
Liu Yao, Zhang Jianhao, Long Men, et al. Effect of crosslinking modification by combined use of borax, NanoSiO2 and NanoTiO2 on moisture permeability and moisture permeability of PVA-based film ［J］. Food Science, 2014, 35(14): 17-23.
［32］　秦丽元, 王秋静, 蒋恩臣, 等. 改性木质素粘结生物质炭包膜尿素肥料性能试验［J］. 农业机械学报, 2016, 47(5): 171-176, 182.
Qin Liyuan, Wang Qiujing, Jiang Enchen, er al. Study on biochar coated urea fertilizer with lignin adhesive modified by different solvents ［J］. Transactions of the Chinese Society for Agricultural Machinery, 2016, 47(5): 171-176, 182.
［33］　张爽, 张二伟, 朱翠萍, 等. γ-聚谷氨酸/壳聚糖复合膜吸附性的影响因素分析［J］. 安徽农业大学学报, 2017, 44(3): 492-495.
Zhang Shuang, Zhang Erwei, Zhu Cuiping, et al. The analysis of factors affecting the adsorption of poly glutamic acid/chitosan composite membrane ［J］. Journal of Anhui Agricultural University, 2017, 44(3): 492-495.
［34］　刘法球. 亚法糖厂滤泥制备生物炭及其缓释肥料的初步研究［D］. 南宁: 广西大学, 2019.
Liu Faqiu. Preliminary study on preparation of biochar and its slowrelease fertilizer by sulfitation method sugar filter mud ［D］. Nanning: Guangxi University, 2019.
［35］　彭仁杰. 聚乙烯醇/硅藻土复合包膜缓释钾肥的制备与应用［D］. 郑州: 郑州大学, 2018.
Peng Renjie. Preparation and application of the polyvinyl alcohol/diatomite composite coated slowrelease potassium fertilizer ［D］. Zhengzhou: Zhengzhou University, 2018.