播种机精密播种深度控制系统*

doi:10.13733/j.jcam.issn.20955553.2021.11.06

中国农机化学报 ›› 2021, Vol. 42 ›› Issue (11): 30-36.DOI: 10.13733/j.jcam.issn.20955553.2021.11.06

播种机精密播种深度控制系统^*

Søren Kirkegaard Nielsen^2,4, Lars Juhl Munkholm², Mathieu Lamandé^2,3, Michael Nørremark¹, Gareth T.C. Edwards⁴, Ole Green⁴

1.奥胡斯大学科学技术学院工程学系,奥胡斯市,8200;
2.奥胡斯大学科学技术学院农业生态系,奥胡斯市,8200;
3.挪威生命科学大学环境科学和自然资源管理学院,奥斯陆市,0001-1800;
4.丹麦农业智能学会,奥胡斯市,8200

收稿日期:2021-10-28 修回日期:2021-11-08 出版日期:2021-11-15 发布日期:2021-11-15
作者简介:Søren Kirkegaard Nielsen,男,1968年生,丹麦人,博士,教授;研究方向为智能农业。E-mail: skn@agrointelli.com译者:冯玉岗,男,1972年生,江苏盐城人,工程师;研究方向为智能农机。E-mail: fygfcx@163.com
基金资助:
*丹麦创新基金研究项目

Seed drill depth control system for precision seeding

Søren Kirkegaard Nielsen^2,4, Lars Juhl Munkholm², Mathieu Lamandé^2,3, Michael Nørremark¹, Gareth T.C. Edwards⁴, Ole Green⁴

1. Aarhus University, Faculty of Science and Technology, Department of Engineering, Aarhus, 8200, Denmark;
2. Aarhus University, Faculty of Science and Technology, Department of Agroecology, Aarhus, 8200, Denmark;
3. Norwegian University of Life Sciences, Faculty of Environmental Sciences and Natural Resource Management, Oslo, 0001-1800, Norway;
4. Agro Intelligence ApS, Aarhus, 8200, Denmark

Received:2021-10-28 Revised:2021-11-08 Online:2021-11-15 Published:2021-11-15

摘要/Abstract

摘要： 适当且均匀的播种深度对作物的发育至关重要,因为它会影响出苗时间和发芽率。在播种作业中的深度变化主要是由于作用在播种机犁刀上土壤阻力的变化引起的,产生的振动导致播种深度不均匀。为此,研制一种低成本概念播种机,并验证动态犁头深度控制系统,并进行田间试验研究。在4 km/h、8 km/h和12 km/h的工作速度下进行主动控制系统的性能评估,测试控制犁头深度为-30 mm时的均匀性和准确性。由犁头位置传感器结合超声波土壤表面传感器获得犁头深度测量数据,在4 km/h、8 km/h和12 km/h作业速度时,系统控制深度与目标犁头平均深度偏移量分别为3.5 mm、5.3 mm和6.3 mm,而没有控制系统时,犁头平均深度偏移量分别为8.0 mm、9.1 mm和11.0 mm。可见,速度对犁头深度控制效果没有显著影响。该控制系统将犁头深度精度优化了15.2%,在95%置信区间下,犁头深度置信范围的绝对降幅为10.4 mm。由于土壤力学特性的变化,标准犁头的深度变异性为±8 mm,当激活犁头深度控制系统时,该变异性降低到±2 mm。采用主动控制系统在12 km/h的运行速度下,比未采用主动控制系统在4 km/h运行速度时的深度控制更准确。

关键词: 条播机, 犁头深度控制系统, 春小麦, 精密播种

Abstract: An adequate and uniform seeding depth is crucial for the homogeneous development of a crop, as it affects time of emergence and germination rate. The considerable depth variations observed during seeding operations-even for modern seed drills-are mainly caused by variability in soil resistance acting on the drill coulters, which generates unwanted vibrations and, consequently, a non-uniform seed placement. Therefore, a proof-of-concept dynamic coulter depth control system for a low-cost seed drill was developed and studied in a field experiment. The performance of the active control system was evaluated for the working speeds of 4, 8 and 12 km/h, by testing uniformity and accuracy of the coulter depth in relation to the target depth of -30 mm. The evaluation was based on coulter depth measurements, obtained by coulter position sensors combined with ultrasonic soil surface sensors. Mean coulter depth offsets of 3.5, 5.3 and 6.3 mm to the target were registered for the depth control system, compared to 8.0, 9.1 and 11.0 mm without the control system for 4, 8 and 12 km/h, respectively. However, speed did not affect the coulter depth significantly. The control system optimised coulter depth accuracy by 15.2% and at 95% confidence interval it corresponded to an absolute reduction in the coulter depth confidence span of 10.4 mm. The spatial variability, due to variation in soil mechanical properties was found to be ±8 mm, across the blocks for the standard drill and when activating the coulter depth control system this variability was reduced to ±2 mm. The system with the active control system operated more accurately at an operational speed of 12 km/h than at 4 km/h without the activated control system.

Key words: seed drill, coulter depth control system, spring barley, precision seeding

中图分类号:

Søren Kirkegaard Nielsen, Lars Juhl Munkholm, Mathieu Lamandé, Michael Nørremark, Gareth T.C. Edwards, Ole Green. 播种机精密播种深度控制系统^*[J]. 中国农机化学报, 2021, 42(11): 30-36.

Søren Kirkegaard Nielsen, Lars Juhl Munkholm, Mathieu Lamandé, Michael Nørremark, Gareth T.C. Edwards, Ole Green. Seed drill depth control system for precision seeding[J]. Journal of Chinese Agricultural Mechanization, 2021, 42(11): 30-36.

参考文献

[1] Chang K F, Hwang S F, Gossen B D, et al. Effects of soil temperature, seeding depth, and seeding date on rhizoctonia seedling blight and root rot of chickpea [J]. Canadian Journal of Plant Science, 2004, 84(3): 901-907.
[2] Guul-Simonsen F, Jorgensen M H, Have H, et al. Studies of plough design and ploughing relevant to conditions in Northern Europe [J]. Acta Agriculturae Scandinavica Section B-Soil and Plant Science, 2002, 52: 57-77.
[3] Håkansson I, Myrbeck Å, Etana A. A review of research on seedbed preparation for small grains in Sweden [J]. Soil & Tillage Research, 2002, 64(1-2): 23-40.
[4] Finlay M J, Tisdall J M, Mckenzie B M. Effect of tillage below the seed on emergence of wheat seedlings in a hardsetting soil [J]. Soil & Tillage Research, 1994, 28(3-4): 213-225.
[5] Petersen C T, Nielsen M H, Rasmussen S B, et al. Jordbearbejdningens Indflflydelse På Pesticidudvaskning Til Markdræn [J]. Miljøstyrelsen, København, 2016: 1-135.
[6] Baskin C C, Baskin J M. Seeds, ecology, biogeography, and evolution of dormancy and germination [M]. San Diego: Academic Press, 1998.
[7] Håkansson I, Arvidsson J, Keller T, et al. Effects of seedbed properties on crop emergence: 1. Temporal effects of temperature and sowing depth in seedbeds with favourable properties [J]. Acta Agriculturae Scandinavica, 2011, 61(5): 458-468.
[8] Durr C, Boiffin J, Fleury A, et al. Analysis of the variability of sugar beet (Beta vulgaris L) growth during the early stages. I. Influence of various conditions on crop establishment [J]. Agronomie, 1992, 12(7): 515-525.
[9] Durr C, Boiffin J, Fleury A, et al. Analysis of the variability of sugar beet (Beta vulgaris L.) growth during the early stages. II. Factors influencing seedling size in field conditions [J]. Agronomie, 1992, 12(7): 527-535.
[10] Kinsner W, Gamby G, Froese R A, et al. A fuzzy seeding depth monitoring and control system[C]. Wescanex 93 Communications, Computers & Power in the Modern Environment Conference, IEEE. IEEE, 1993.
[11] Rivera D, Jáuregui B M, Peco B. The fate of herbaceous seeds during topsoil stockpiling: Restoration potential of seed banks [J]. Ecological Engineering, 2012, 44: 94-101.
[12] Brennan E B, Leap J E. A comparison of drill and broadcast methods for establishing cover crops on beds [J]. Hortscience, 2014, 49(4): 441-447.
[13] Garrido M, Conceição L A, Baguena E M, et al. Evaluating the need for an active depth-control system for direct seeding in Portugal [C]. In: Proceedings of the 8th European Conference on Precision Agriculture. Wageningen Academic Publishers, Wageningen, 2011: 371-381.
[14] Kiani S. Automatic on-line depth control of seeding units using a non-contacting ultrasonic sensor [J]. Int. J. Nat. Eng. Sci, 2012, 6: 39-42.
[15] Suomi P, Oksanen T. Automatic working depth control for seed drill using ISO 11783 remote control messages [J]. Computers & Electronics in Agriculture, 2015, 116: 30-35.
[16] Weatherly E T, Bowers Jr C G. Automatic depth control of a seed planter based on soil drying front sensing [J]. Transactions of the Asae, 1997, 40(2): 295-305.
[17] Nielsen S, Kirkegaard, Nørremark M, et al. Sensor and control for consistent seed drill coulter depth [J]. Computers & Electronics in Agriculture, 2016, 127: 690-698.
[18] Nielsen S, Kirkegaard, Munkholm L J, et al. Seed drill instrumentation for spatial coulter depth measurements [J]. Computers and Electronics in Agriculture, 2017, 141: 207-214.
[19] Jensen T, Munkholm L J, Green O, et al. Soil Surface Roughness using cumulated gaussian curvature[C]. International Conference on Computer Vision Systems. Springer, Cham, 2015.

播种机精密播种深度控制系统^*

Seed drill depth control system for precision seeding

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 2

编辑推荐

Metrics

本文评价

[1]	刘洋, , 杨善东, 魏忠彩, , 邱田元, , 盖金星, , 胡培杰. 甜菜生产全程机械化技术与装备研究进展[J]. 中国农机化学报, 2022, 43(3): 36-46.
[2]	陈为鹏, 胡培杰, 张宝昌, 邱田元, 杨善东. 交错苗带式大豆免耕精量播种机设计与试验[J]. 中国农机化学报, 2022, 43(2): 1-7.